Effect of partial substitution with precooked rice and amaranth flours on the technological and nutritional characteristics of bread
Main Article Content
Abstract
Developing innovative products by rescuing ancestral raw materials with high nutritional value is a challenge for researchers, the objective of this research was to develop breads with high nutritional quality by partially substituting wheat flour with precooked amaranth and brown rice flour. To establish the formulations, the Design Expert Ver 8.0 software was used; the substitution levels cover a range from 5% to 30%; the sponge method was used because it offers better crumb quality. Bread quality was analyzed in terms of chemical composition, specific bread volume, width/height ratio of the central slice, crumb structure and firmness, and sensory analysis. Starch thermal properties were studied in terms of starch hydration properties. The incorporation of the flour blend increased protein, lipid, fiber, ash and myoinositol phosphate contents. The best mixture contains 20% amaranth and 10% brown rice, the bread obtained has a soluble/insoluble fiber ratio close to 1:2, which presents the most effective physiological action and has a protein content that could cover the protein requirement in adults.
Downloads
Article Details
This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
Material appearing in the journal may be reproduced and cited, provided that it complies with the conditions established in the licenses of the published articles Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
References
NTE INEN 3050. (2016). Rice flour, requirements. Quito: Instituto Ecuatoriano de Normalización.
NTE INEN 616. (June 11, 2016). Determination of cadmium, lead and ochratoxin in flour from the husks of two varieties of cocoa in Ecuador. Quito: Instituto Ecuatoriano de Normalización.
Almeida, E., Chang, Y., & Steel, C. (2013). Effect of resistant starch on physicochemical properties of wheat dough and bread. Food Science and Technology, 50, 545-553.
Altamirano, M., Ortola, M., & Castello, M. (2017). Study of the hydration kinetics of white and brown " Senia" type rice . Valencia: Polytechnic University of Valencia.
Alvarez, L., Gallagher, E., Reguera, L., & Haros, M. (September 2009). Nutritional value and chemical composition of pseudocereals as gluten-free ingredients. 240-257.
AOAC (1999). AOAC 999.11. Washington, Rockville, Maryland: Association of Official Analytical Chemists.
AOAC 2001.11. (2001). Cereal nitrogen method. Rockville, Maryland: Association of Official Analytical Chemystri.
AOAC 2011.25. (2011). Fiber methods the quantifies. Rockville, Maryland : Association of Official Analysisi Chemicals.
AOAC 923.03. (2005). Official method for determining ash. Virginia: Association of Official Analysis Chemicals.
AOAC 945.16. (1990). Oil in Cereal . Rockville, Maryland : Association of Official Analytical Chemists.
AOAC 985.35. (2005). Official method for the determination of sodium. Rockville, Maryland : Association of Official Analysis Chemicals.
AOAC 985.35. (2016). Method AOAC for calcium recovery. Arlington Virginia: Association of Official Analytical Chemists.
Banerji, A., Ananthanarayan, L., & Lele, S. (May 24, 2018). Rheological and nutritional studies of amaranth-enriched wheat chapatti (Indian flatbread). Food Science Technology Institute.
Bustos, D., & Guerrero, T. (2015). Study of the partial substitution of wheat flour by raw and cooked amaranth flour in bread making. Quito: Repositorio Universidad Tecnológica Equinoccial.
Cedeño, M., & Galarza, E. (2013). The guarantee trust as a financing mechanism for MSMEs engaged in dairy production in the city of Cayambe. Retrieved from Salesiana: https://dspace.ups.edu.ec/handle/123456789/5823
D'Amico, S., Schoenlechner, R., Tömösközia, & Langó, B. (2020). Investigation of the effect of pentosan addition and enzymatic treatment on the rheological properties of millet flour-based model dough systems. ELSEVIER, 91, January.
Galarza, I, & Falcón, S. (2013). Amaranth, nutritional alternative. Revista de docencia , 16-21.
Haros, M., Carlsson, N., Almgrem, A., Alminger, L., Sandberg, S., & A. (September 30, 2009). Phytate degradation in human intestinal Bifidobacterium pseudocatenulatum ATCC27919 isolates and their probiotic potential. ELSEVIER, 135, 7-14.
Haros, Rosel, & Bebedito (2002). Effect of different carbohydrates on fresh bread texture and bread hardening. SpringerLink, 425-430.
Iglesias- Puig, E., Monedero, V., & Haros, M. (2015). Bread whith whole quinoa flour and Bifidobacterial phytase increases dietary mineal intake and bioavaibility. LWT-Food Science and Technology, 60, 71-77.
Iglesias-Puig, Monedero, & Haros (January 2015). Bread with whole grain quinoa flour and bifidobacterial phytases increases dietary mineral intake and bioavailability. 60.
Jaime, L., Molla, E., Fernandez, A., & Martin-Cabrejas, M. L.-A. (2001). Structural carbohydrate differences and potential source of dietary fiber of onion tissues. Journal of Agricultural and Food Chemystry, 50, 122-128.
Kamoto, J., Kasapila, W., & Manani, T. (September 28, 2018). Use of fungal alpha amylase and ascorbic acid in the optimization of bread blended with wheat flour and grain amaranth. PubMed Central.
Kumar, V., Sinha, A., Makkar, H., & Becker, K. (June 15, 2010). Dietary roles of phytate and phytase in human nutrition: A review. ELSEVIER, 120, 949-959.
Lorenz, B., & Wright, B. (1984). Phytate and tannin content of amaranth. ELSEVIER, 14, 27-34.
Marianda, C., Ponce, S., & Haros, M. (November 2019). Evaluation of the technological and nutritional quality of bread enriched with amaranth flour. ELSEVIER, 114.
Matias, G., Hernández, B., Caballero, V., Torres, N., Espinoza, V., & Ramirez, L. (2018). Current and potential uses of Amaranth. Journal of Negative and non-positive results, 423-435.
Mesas, J., & Alegre, T. (July 15, 2002). BREAD AND ITS ELABORATION PROCESS. 3, 307-313.
Meullenet, J., & Carpenter, J. (1998). Relationship between sensory and instruments texture profile attributes. Fayetteville: Dept. of Food Science University of Arkansas.
Miranda, K., Sanz- Ponce, N., & Haros, M. (2019). Evaluation of technological and nutritional quality of bread enriched with. Food Science and Technology , 1-8.
NTE-INEN 518. (1980-12). Determination of moisture in cereal flours. Quito: Instituto Ecuatoriano de Normalización.
Osvald, M., Tamás, C., Raskszeg, M., Tomoskozi, S., & Bekes, F. (2009). Effect of incorporated amaranth albumins on the. Journal of Food and Nutrition Research, 6, 335-340.
Penella, S., Collar, C., & Haros, M. (2008). ELSEVIER, 48, 751-721.
Penella, S., Wronkowska, M., Smietana, S., & Haros, M. (March 2013). Effect of whole amaranth flour on the properties and nutritional value of bread. ELSEVIER, 50, 679-685.
Penella-Sanz, J. (March 2013). Effect of whole amaranth flour on the properties and nutritional value of bread. ELSEVIER, 50, 679-685.
Pilataxi, M. (2013). Elaboration and nutritional evaluation of bread with amaranth flour . Riobamba: University of Guayaquil.
Puig, I., Monedero, V., & Haros, M. (2015). Bread with whole-grain quinoa flour and bifidobacterial phytases increases dietary mineral intake and bioavailability. ELSEVIER, 60, 71-77.
Ramos, K., Ponce, S., & Haros, M. (November 2019). Evaluation of the technological and nutritional quality of bread enriched with amaranth flour. ELSEVIER, 114, 1-27.
Reguera, M., & Haros, C. (2017). structure and composition of kernels. Pseudocereals: Chemestry and Technology, 28-48.
Repo, R., Carrasco, V., & Valdez, J. (2017). Carbohydrates of kernels. In M. Haros, & R. Schoenlechiner, Pseudocereals: Chemistry and Technology (pp. 49-61). Oxford, UK,: John Wiley and Sons, Ltd.
Rivera, V. (2014). Effect of maturity stage of Cavendish banana on flour and gel hydration. Guayaquil: Escuela Superior Politecnica del litoral.
Salas, M., & Haros (September 2016). Evaluation of the technological, nutritional and sensory quality of bakery products by substitution of wheat flour with rice wholemeal flour. DIGITAL.CSI.
Salas, M., & Haros, M. (2016). Evaluation of technological, nutritional and sensory quality of bakery products by substitution of wheat flour for whole rice flour. Brazilian Journal Food Technology, 1-9.
Salas, M., & Haros, M. (2016). Evaluation of the technological of bakery products produced whit. Brazilian Journal of Food Technology, 19, 1-9.
Salas, -S. J., Bulló, M., Pérez-Heras, A., & Ros, E. (2006). Dietary fibre, nuts and cardiovasscular diseases. Brithish Journal of Nutrions, 45-51.
Santamarìa, J. (2017). Study of the drying and cooking stages to obtain fast cooking "senia" rice. Valencia: Universidad Politecnica de Valencia.
Sanz-Penella, Tamayo-Ramos, Sanz, & Haros (2013). Effect of whole amaranth flour on the properties and nutritional value of bread. ELSEVIER, 679-685.
Silva. (2016). High performance factors and practices influencing work climate: a case analysis. SciELO, 26.
Siwatch, M., Yadav, R., & Yadav, B. (2019). Chemical, physicochemical, bonding and microstructural properties of amaranth (Amaranthus hypochondriacus) flour as affected by different processing treatments. Wagningen Academic, 3-13.